concrete and quarry dust and journal

your location:

Cases Center

concrete and quarry dust and journal

concrete and quarry dust and journal

Use of Quarry Dust to Replace Sand in Concrete An

International Journal of Scientific and Research Publications, Volume 3, Issue 12, December 2013 1 ISSN 2250-3153 ijsrp Use of Quarry Dust to Replace Sand in Concrete

get price

Introduction to Quarry-Dust as Partial Replacement

May 19, 2020 Sudhir S. Kapgate and S. R. Satone,Effect of quarry dust as partial replacement of sand in concrete Indian streams research journal,vol.3(5), 2013, ISSN 2230-7850. R Chandana Sukesh, Katakam Bala Krishna, P.Sri Lakshmi Sai Teja, S.Kanakambara Rao, Partial Replacement of Sand with Quarry Dust in Concrete.

get price

Concrete And Quarry Dust And Journal

Use of Quarry Dust to Replace Sand in Concrete An Experimental Study329 Кб. For this concrete mix, quarry dust was added for replacement of sand from 0% to in step of 10%. ijsrp International Journal of Scientific and Research Publications, Volume 3, Issue 12, December 2013 ISSN 2250-3153 2 B...

get price

Partial Replacement of Sand by Quarry Dust in Concrete

International Journal of Scientific and Research Publications, Volume 5, Issue 7, July 2015 1 ISSN 2250-3153 Partial Replacement of Sand by Quarry Dust in Concrete Sumit L. Chauhan, Raju A.Bondre Assistant Professor P. I. G. C. E. Nagpur Abstract- The paper describe the role of quarry dust In the of various complex silicates are formed, causing the mass to construction of buildings and other

get price

Properties of Micro Fine Quarry Dust Concrete

the title of the work and journal citation in the form of a proper scientific referencing. PROPERTIES OF MICRO FINE QUARRY DUST CONCRETE NUR HANANI ABDUL RAHIM1*, KARTINI KAMARUDDIN2, HAMIDAH MOHD SAMAN3 1, 2, 3 Universiti Teknologi MARA (UiTM), Shah Alam, Selangor, Malaysia Index Terms Micro Fine Quarry Dust Cement Replacement Compressive Strength

get price

MECHANICAL BEHAVIOUR OF CONCRETE MADE WITH

50% quarry dust From figure 2 we can find out that 60% is the optimum replacement of cement with GGBS in both natural sand and quarry dust. Table 6 shows the split strength values for concrete with different percentages of GGBS with 100% natural sand and 50% quarry dust. Table 6. split tenile strength of M20 concrete over

get price

(PDF) Use of Quarry Dust to Replace Sand in Concrete An

A. Mix proportioningTwo grades of concrete M20 and M25 having nominal mix proportion of 1:1.5:3 and 1:1:2 respectively were used by weight and w/c ratio was fixed according to the slump requirement of 60mm. For this concrete mix, quarry dust was added for replacement of

get price

Partial Replacement of Fine Aggregates with Quarry Dust

International Journal of Engineering Trends and Applications (IJETA) Volume 5 Issue 3, May-Jun 2018 ISSN: 2393-9516 ijetajournal Page 57 Partial Replacement of Fine Aggregates with Quarry Dust and Marble Powder in Concrete

get price

USE OF QUARRY DUST IN CONCRETE AS REPLACEMENT FOR

construction work. Quarry dust is produced from crusher unit and each crusher unit is produced nearly 22% to 27% of dust. This dust is completely waste material for crusher unit but quarry dust is useful for construction work as sand. If we mix quarry dust in sand then only 65% to 75% of sand replaced by quarry dust because strength of concrete is

get price

high performance concrete using quarry dust as fine aggregate

Quarry dust, High performance concrete, Sand, Steel fibre, Silica fume. Reference [1]. ACI 211.4R-93 (Reapproved 1998), Codel provision. [2]. Anitha selva sofia.S.D, Gayathri.R and Swathi.G ‘Experimental investigation on quarry dust concrete with chemical admixture’, Int. Journal of Latest Research in Science and Technology, Vol-2, issue-2

get price

High performance concrete using quarry dust as fine

ABSTRACT² This paper describes the experimental study of High-Performance concrete with quarry dust as fine aggregate in addition of steel fibre. To over-come the difficulties due to excessive sand mining, quarry dust was used as fine aggregate. Quarry dust is

get price

Introduction to Quarry-Dust as Partial Replacement

May 19, 2020 Sudhir S. Kapgate and S. R. Satone,Effect of quarry dust as partial replacement of sand in concrete Indian streams research journal,vol.3(5), 2013, ISSN 2230-7850. R Chandana Sukesh, Katakam Bala Krishna, P.Sri Lakshmi Sai Teja, S.Kanakambara Rao, Partial Replacement of Sand with Quarry Dust in Concrete.

get price

Research Paper Structural Properties of Laterite Quarry

The cement and quarry dust are both suitable for general purpose concrete works. Table 1: Chemical Properties of cement and Quarry dust used Component CaO Al 2 O 3 SiO 2 Fe 2 O 3 SO 3 Cl MgO TiO 2 K 2 O LOI Cement 64.34 4.51 20.79 2.64 1.48 0.03 1.66 1.26 1.7 Quarry dust 2.43 16.72 65.66 3.92 - 3.56 2.21 0.88 -

get price

EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL

quarry dust also contains a similar property of river sand. quarry dust is used in concrete to minimize the demand of river sand. maximum exploitation of sand is to be minimized to protect the river beds, shore structures from erosion. to reduce disposal and pollution problems emanating from

get price

Partial Replacement of Fine Aggregates with Quarry Dust

International Journal of Engineering Trends and Applications (IJETA) Volume 5 Issue 3, May-Jun 2018 ISSN: 2393-9516 ijetajournal Page 57 Partial Replacement of Fine Aggregates with Quarry Dust and Marble Powder in Concrete

get price

Characteristic studies on the mechanical properties of

was studied with various proportions of quarry dust (CM 1:3, CM 1:2, and CM 1:1). The experimental results showed that the addition of quarry dust for a fine to coarse aggregate ratio of 0.6 was found to enhance the compressive properties as well as elastic modulus. Key words: Concrete, quarry dust, fillers, elastic modulus, compressive strength.

get price

Stone Dust in Concrete: Effect on Compressive Strength

found that the compressive and flexural strength of concrete made of Quarry Rock Dust are nearly 10% more than the conventional concrete (Suribabu et al., 2015). In the present study it is proposed to investigate the optimum replacement of river sand with stone dust for concrete in term of compressive strength performance at 7 days and 28 days. II.

get price

MECHANICAL BEHAVIOUR OF CONCRETE MADE WITH

50% quarry dust From figure 2 we can find out that 60% is the optimum replacement of cement with GGBS in both natural sand and quarry dust. Table 6 shows the split strength values for concrete with different percentages of GGBS with 100% natural sand and 50% quarry dust. Table 6. split tenile strength of M20 concrete over

get price

Evaluation Of Mechanical And Durability Properties Of

JETIR1809718 Journal of Emerging Technologies and Innovative Research (JETIR) jetir 482 Evaluation Of Mechanical And Durability Properties Of Concrete Made By Using Dolomite,Fly Ash And Quarry Dust As Partial Replacements Of Cement And Sand 1 N. Usha Rani, 2 Dr.S.M.V.Narayana 1 M.Tech.,(PG Scholar), 2Professor & Head of the Department

get price

Research Paper STRENGTH AND DURABILITY STUDIES ON

Quarry dust gives strength to concrete. In the present study fine aggregate has been replaced by quarry dust. The present work is undertaken to investigate the strength tests, rapid chloride permeability test and corrosion resistance properties of the quarry dust replaced concrete

get price

Effect of Glass Fibers, Fly Ash and Quarry Dust on

Aug 29, 2018 Rai Baboo, Kumar Sanjay and Satish Kumar 2014 Effect of Fly Ash on Mortar Mixes with Quarry Dust as Fine Aggregate Journal of Adavnces in Material Science and Engineering 1 1-7 [2] Krishnamoorthi A and Mohan Kumar G 2013 Properties of Green Concrete Mix by Concurrent use of Fly ash and Quarry dust IOSR Journal of Engineering 3 48-54

get price

59 SUBSTITUTION OF QUARRY DUST TO SAND FOR

crusher dust in concrete only. Investigations on full replacement of sand for mortar in brick masonry with 59 crusher dust as is available from the crusher are reported in this paper. Also, the fines below 150 micron size are removed from this unrefined crusher dust and the micro fines removed crusher dust is used for full replacement of

get price

CiteSeerX — Strength and durability properties of concrete

This paper presents the feasibility of the usage of Quarry Rock Dust as hundred percent substitutes for Natural Sand in concrete. Mix design has been developed for three grades using design an approach IS, ACI, USBR, RN.No.4 and BRITISH for both conventional concrete and quarry dust concrete. Tests were conducted on cubes and beams to study the

get price

high performance concrete using quarry dust as fine aggregate

Quarry dust, High performance concrete, Sand, Steel fibre, Silica fume. Reference [1]. ACI 211.4R-93 (Reapproved 1998), Codel provision. [2]. Anitha selva sofia.S.D, Gayathri.R and Swathi.G ‘Experimental investigation on quarry dust concrete with chemical admixture’, Int. Journal of Latest Research in Science and Technology, Vol-2, issue-2

get price

Analysis of Concrete Made from Quarry Dust

alternative materials, such as quarry dust, for SCC applications. Results from rheological measurements on pastes and concrete mixes incorporating limestone or quarry dust were compared. It was found that the quarry dust, as supplied, could be used successfully in the production of SCC. However, due to its

get price

Experiment on Foam Concrete with Quarry Dust as Partial

of concrete made of quarry dust and results were compared with the control foam concrete. It is found that the compressive strength of foam concrete made of quarry dust are nearly 40 % more than the control foam concrete. replacement material to sand as fin. Keywords— Foam Concrete, Aerated concrete, Foaming agent, Bubbles.

get price

Research Paper Structural Properties of Laterite Quarry

The cement and quarry dust are both suitable for general purpose concrete works. Table 1: Chemical Properties of cement and Quarry dust used Component CaO Al 2 O 3 SiO 2 Fe 2 O 3 SO 3 Cl MgO TiO 2 K 2 O LOI Cement 64.34 4.51 20.79 2.64 1.48 0.03 1.66 1.26 1.7 Quarry dust 2.43 16.72 65.66 3.92 - 3.56 2.21 0.88 -

get price

Stone Dust in Concrete: Effect on Compressive Strength

found that the compressive and flexural strength of concrete made of Quarry Rock Dust are nearly 10% more than the conventional concrete (Suribabu et al., 2015). In the present study it is proposed to investigate the optimum replacement of river sand with stone dust for concrete in term of compressive strength performance at 7 days and 28 days. II.

get price

Evaluation Of Mechanical And Durability Properties Of

JETIR1809718 Journal of Emerging Technologies and Innovative Research (JETIR) jetir 482 Evaluation Of Mechanical And Durability Properties Of Concrete Made By Using Dolomite,Fly Ash And Quarry Dust As Partial Replacements Of Cement And Sand 1 N. Usha Rani, 2 Dr.S.M.V.Narayana 1 M.Tech.,(PG Scholar), 2Professor & Head of the Department

get price

Partial Replacement of Sand with Quarry Dust in Concrete

-The reduction in the sources of natural sand and the requirement for reduction in the cost of concrete production has resulted in the increased need to identify substitute material to sand as fine aggregates in the production of concretes especially in Concrete. Quarry dust, a by-product from the crushing process during quarrying activities is one of such materials.

get price

Stone crusher dust as a fine aggregate in Concrete for

) is higher than the conventional concrete. The durability of quarry rock dust concrete under sulphate and acid action is higher than the conventional concret. Similarly water Absorption found to be more in the concrete containing crusher dust2. The overall workability value of quarry rock dust concrete in terms of slump as well as

get price

Experimental Study on Concrete and Cement Plaster Using

Quarry Rock Dust as hundred percent substitute for Natural Sand in concrete. Design Mix for M30 and M40 has been calculated using IS 10262-2009 for both conventional concrete and quarry dust concrete. Tests were conducted on cubes, cylinders and prisms to study the strength of concrete by using Quarry Rock Dust and the results were compared

get price

Studies on Fresh and Hardened Properties of concrete

May 01, 2014 Publication: Materials Journal. Volume: 111. Issue: 3. Appears on pages(s): 283-290. Keywords: quarry dust; recycled aggregate concrete; resource conservation recycled aggregate. Date: 5/1/2014. Abstract: Recycled aggregate obtained from crushed concrete rubble can be reused in building industry, instead of being stored.

get price

Behaviour of Concrete on Replacement of Sand with Quaries

2.1 Quarry rock dust: The Quarry Rock Dust obtained from local resource Sri Kanaka Durga Fal-G Brick products, Visakhapatnam was used in concrete to cast test cubes and beams. The physical and chemical properties of Quarry Rock Dust obtained by testing the samples as per Indian Standards are listed in Tables 1 and 2, respectively.

get price

Experimental Study on Use of Quarry Dust and Fly Ash with

From the results of the experimental study, the following conclusions were drawn on concrete when quarry dust and fly ash are added in different proportions. 1) With the addition of 15% of fly ash and 15% of quarry dust the compressive strength increases to 22% then control mix M40 grade at 28 days.

get price

Effect of Glass Fibers, Fly Ash and Quarry Dust on

Aug 29, 2018 Rai Baboo, Kumar Sanjay and Satish Kumar 2014 Effect of Fly Ash on Mortar Mixes with Quarry Dust as Fine Aggregate Journal of Adavnces in Material Science and Engineering 1 1-7 [2] Krishnamoorthi A and Mohan Kumar G 2013 Properties of Green Concrete Mix by Concurrent use of Fly ash and Quarry dust IOSR Journal of Engineering 3 48-54

get price

Effect of Fly Ash and Quarry Dust on Properties of Concrete

The studies are to be made to ascertain the properties of M20 grade concrete by using fly ash as partial cement replacement and Quarry dust as partial fine aggregate

get price